4 or 5 PANEL MIRRORS

4/5 Panel Mirror

 

4 or 5 Panel Mirror’s

$24.33 each

GOLF CAR BATTERY 36/48 VOLT DISCHARGE METER

 

Voltage indicator comes in 36 and 48 volt.  Keep track of battery discharge. Don’t guess when batteries are low, let this meter show you.

$59.33 each.

 

GOLF CAR TIRES and TIRE PRESSURE

Always remember that tire pressure is very important!  The standard golf car tire requires 22lbs of air pressure at all times, no more – no less.  It is so important that, if you don’t maintain this level of air, it will put an extreme amount of stress on your batteries.  This will decrease the life of your batteries, and your golf car will loose power and may even stop you dead on the golf course, or where ever you are.

I have seen tires separate from the wheel for lack of air.  When this happens the wheel, and tire need to be taken off of the golf car and repaired.  Hopefully the tire can be saved.  In the event it can not be spared, you will have the added expense of a tire, and possibly a wheel.  There is also labor, and a service call to consider.  A simple thing like air can prevent this from happening.  Spare yourself the expense, and lost time your could be enjoying your golf car, by adding air when needed,

A costumer called recently because his golf car would not even climb a small incline.  This is a long time customer who didn’t realize the importance  of air pressure.  He called me 50 miles away because he thought his batteries might be the issue.  When I arrived at the customer location and checked the batteries, the batteries checked out okay.  I noticed one of the golf car tires appeared to be low on air pressure.  Upon checking the tires with my air gauge the tires were all low on air. Some of the tires did not even register air in them at all. You can’t always tell when golf tires need air because they are so rigid. I filled all four of his tires to 22lbs, and the problem was solved.  His golf car was not sluggish any more. The golf car drove at the speed it was supposed to, even in grass and up hills.

You will get a lot more distance between charges, and the life of your batteries will be extended a lot longer,  It could turn out to be a warranty issue, if your batteries loose their life pre maturely.  These reasons are why air pressure is so important.  22lbs, 22lbs, 22lbs.  Check them often!  Golf car tires are notorious for loosing air.  Don’t get caught with your tires down.  Take good care, check your air.

HARNESS FOR GOLF CAR HEADLIGHT AND TAILLIGHT INSTALL

HEADLIGHT/TAILLIGHT HARNESS

 

HARNESS INCLUDES:  $54.88

One main fuse for power supply, Sub Harness for horn and floor button. hor and floor button sold separately, relay. wiring diagram included

COMPLETE HARNESS FOR GOLF CAR

 

KIT no. 970 $121.10

Kit includes: Push pull switch, Turn signal switch, 18 inch cover, Flasher, Horn, 12v power plug, Horn button, Sub harness, 6 wire blade fuse board, Fuses, cover, and 12v relay included.

GOLF CAR FUSE BLOCKS

FUSE BLOCK WILL SHOW BLOWN FUSE BY RED LED RESPONSE. PART 978 $7.89 (FUSES NOT INCLUDED).

36 VOLT TO 12 VOLT VOLTAGE REDUCER

USED WITH LIGHT KITS AND ELECTRICAL ACCESSORIES

 

36v to 12v 25 amp voltage reducer

$89.95

 

48 VOLT TO 12 VOLT VOLTAGE REDUCER

 

48v to 12v 25 amp voltage reducer fo golf car accessories

$89.95

 

MAINTAINING GOLF CAR BATTERIES

To prolong the life of deep cycle batteries, you must use distilled water in them. Take each cap off each battery and check each cell about once a month. If lead is exposed in the bottom of the cell you are looking in, add water. Note: a battery filler is a good thing to purchase to get the right level of water each time. I sell them for $10.00 dollars. Very handy!

If batteries are under warranty, the proper water level is important. If the batteries are under filled or over filled, the warranty is nullified. Over filling will cause acid to spill over batteries, and make contact with the frame of the golf car and on the surface you park. The acid will eat any thing that is not plastic. I recommend you place a plastic mat on the surface, under the batteries to prevent this from happening.

It is important to make sure the nut on each stud where the cable is connected is tight so the battery does not arch and melt the battery post or blow up the battery. This is not a warranty issue, it is human error.

Use battery protectant spray to eliminate acid forming, and eating cables in half. The golf car will stop dead if the cable brakes. You can use a water hose with a pressure nozzel on it to clean batteries off. WATER WILL NOT HURT ANYTHING BY SPRAYING UNDER THE SEAT IN THE BATTERY COMPARTMENT. It will save you a lot of head aches and break downs. Simple maintenance is a smart thing to do. You won’t have to call a golf car mechanic as often.

KEEP THE BATTERIES CHARGED AT ALL TIMES!